Lockheed YO-3 Quiet Star

YO-3 Quiet Star
	NASA's YO-3A departing Armstrong Flight Research Center
Role	Night reconnaissance
National origin	United States
Manufacturer	Lockheed Missiles and Space Company
First flight	1969
Introduction	1969
Retired	1971
Primary user	United States Army
Produced	1969–1970
Number built	11
Developed from	Schweizer SGS 2-32

The Lockheed YO-3 Quiet Star is an American single-engined, propeller-driven aircraft that was developed for battlefield observation during the Vietnam War. Designed to be as quiet as possible, it was intended to observe troop movements in near-silence during the hours of darkness.

Design and development

The YO-3A was designed to a United States Army specification of 1968, which called for an observation aircraft that would be acoustically undetectable from the ground when flying at an altitude of 1,500 feet (457 m) at night.

Lockheed Missiles and Space Company located in Sunnyvale, California was contracted to produce two prototype aircraft. In 1966, the company built two QT-2 "Quiet Thrusters", using modified Schweizer SGS 2-32 gliders. The prototype QT-2s were then modified to the QT-2PC "PRIZE CREW" configuration. The QT-2PC had a silenced engine and a slow-turning propeller for quiet operation.^[1]

Following operational trials with the QT-2PC in Vietnam, a production aircraft, designated the YO-3A was ordered. This aircraft's design was also based on the Schweizer SGS 2-32 glider. Like the QT-2PC, the YO-3A has a large wingspan and a larger canopy area for observation. Two crew members (a pilot and an observer) are seated in tandem. The observer is located at the front of the cockpit. The YO-3A is an all-metal low-wing monoplane of semi-monocoque construction. The control surfaces of the YO-3A including the ailerons and rudder are fabric-covered. The engine cover, canopy, engine exhaust shroud, wing-root fairings, and wheel-well fairings were constructed of fiberglass. The YO-3A has retractable tailwheel-type landing gear.^[2]

The YO-3A was powered by an air-cooled, six-cylinder, horizontally opposed, fuel-injected, Continental Model No. IO-360D engine. The engine is coupled to a slow-turning propeller through a belt pulley-drive system. The propeller reduction ratio is 3.33:1. Originally equipped with a six-bladed ground-adjustable-pitch propeller, this was replaced in March 1971 with a three-bladed laminated constant-speed wooden propeller designed by Ole Fahlin. The engine cowling and firewall were lined with fiberglass material to dampen and contain engine noise.^[2]

The YO-3A is equipped with an Asymmetrical Exhaust System. A crossover exhaust pipe is used to remove exhaust from the left bank of engine cylinders to the right side of the engine compartment. This crossover joins the right bank exhaust pipe and exits along the lower right side of the engine compartment. The exhaust gases are then moved through an acoustical fairing into a dissipating and resonating muffler continuing to the aft end of the fuselage.^[2]

Nine of the eleven YO-3As produced operated in South Vietnam, at night, from 1970 to 1971 (Late June 1970 to September 1971) and, although three were destroyed in crashes, none were damaged by enemy fire or shot down.^[3] The YO-3A was very successful in spotting movement by the Viet Cong and North Vietnam Army (NVA) operating in South Vietnam.

Operational history

Vietnam War

Following combat evaluation of the QT-2s in Vietnam by the Army, nine production YO-3As were sent to Long Thanh North, Vietnam, in 1970. Shortly after, three were sent to the 220th Aviation Company, Phu Bai and two to Binh Thuy Air Base. Observations were initially made visually (80%), later followed on with a Night Vision Aerial Periscope developed by Xerox Electro-Optical of Pasadena, California. The mission equipment on the YO-3A was a Night Vision Aerial Periscope with infrared illuminator. One YO-3A was equipped with a laser target designator. The laser designator system was never used.

The YO-3A operated silently at 1,000 feet, or lower, depending on terrestrial background noise. Some pilots were known to have gone unobserved over the enemy at 200 feet. Occasionally, daylight flights were made over the rivers. Crew chiefs would monitor the YO-3A flying over the maintenance section prior to deployment, listening for rattles, whistles or other noises. The propeller, even at 500 feet over the maintenance area, made only a light flutter, heard just as it approached. This was followed by a light rushing of wind over the wings. There was no audible sound once the aircraft had passed over. If any abnormal noises were heard, the aircraft returned to the runway, where duct tape and other measures were employed to quiet noticeable sounds.^[4]

Postwar usage

After Vietnam, two YO-3As, 69-18006 and 69–18007, were used by the Louisiana Department of Fish and Game. The aircraft was effective at catching poachers. The FBI eventually acquired the aircraft, and operated the type for several years, assisting the apprehension of kidnappers and extortionists.

NASA took possession of one YO-3A, 69–18010. Following service with the U.S. Army this aircraft was transferred to an airframe and powerplant mechanics school. NASA's Ames Research Center located at Moffett Federal Airfield in California acquired the YO-3A from the school in 1977. NASA equipped the aircraft with wing-tip and tail-mounted microphones. These microphones were used to record the in-flight acoustic signatures of a variety of U.S. Army helicopters and Tiltrotor aircraft. The YO-3 was also used to measure sonic booms from the Lockheed SR-71 Blackbird. In 1997, the NASA YO-3A was transferred to the Dryden Flight Research Center (now Armstrong Flight Research Center) at Edwards Air Force Base, in California. The YO-3A remained in a flyable storage state until October 2004. Then the YO-3A was flown back to Ames to support rotorcraft research again for nearly two years before once again returning to Dryden. In 2015, the aircraft was retired by NASA and sold by the General Services Administration at auction to the Vietnam Helicopters Museum.^[5]

Variants

QT-1 Quiet Thruster: Proposed single-seat powered glider based on the Schweizer SGS 2-32, not built.^[6]
QT-2: Two modified Schweizer X-26 two-seat sailplanes for evaluation, later modified with sensor packages as the QT-2PC.^[6]
QT-2PC PRIZE CREW: Two QT-2s with combat sensor packages for evaluation in Vietnam theatre, one reduced to spares and the other returned to the United States Navy as the Schweizer X-26B.^[6]
Q-Star: Modified Schweizer SGS 2-32 for engine/propeller development.^[6]
YO-3A: Production aircraft for the United States Army, 11 built

Operators

Military operators

United States

United States Army

Civil operators

United States

Surviving aircraft

69-18000 – YO-3A in storage at the United States Army Aviation Museum in Fort Novosel, Alabama.^[7]
69-18001 – YO-3A on static display at the Hiller Aviation Museum in San Carlos, California.^[8]^[9]
69-18005 – YO-3A on static display at the Museum of Flight in Seattle, Washington.^[10]
69-18006 – YO-3A on static display at the Pima Air & Space Museum in Tucson, Arizona.^[11]
69-18007 – YO-3A in storage at the Western Museum of Flight in Torrance, California.^[3]
69-18010 – YO-3A in storage at the Vietnam Helicopters Museum in Concord, California.^[12]^{[failed verification]}

Specifications

General characteristics

Crew: 2
Length: 29 ft 4 in (8.94 m)
Wingspan: 57 ft (17 m)
Wing area: 213.1 sq ft (19.80 m²)
Aspect ratio: 1:7 at 80kts IAS
Max takeoff weight: 3,800 lb (1,724 kg)
Powerplant: 1 × Continental Model No. I0-360D engine , 210 hp (156 kW) at 2800 rpm
Propellers: 3-bladed laminated wood, constant-speed propeller.

Performance

Maximum speed: 103 mph (166 km/h, 90 kn)
Cruise speed: 80.6 mph (129.7 km/h, 70.0 kn)
Stall speed: 64.4 mph (103.6 km/h, 56.0 kn)

References

Notes

^ "QT-2PC PRIZE CREW". Retrieved 2015-05-03.
^ ^a ^b ^c "YO-3A "Quiet Star" Silent Stealth Airplane". Vietnam Helicopters Museum. Retrieved 2015-05-02.
^ ^a ^b "Lockheed YO-3A Quiet Star". Western Museum of Flight. Retrieved 16 November 2020.
^ Andrade 1979, p. 140.
^ Peter Merlin, Public Affairs NASA Armstrong Flight Research Center (15 April 2015). "Quiet Research Aircraft Retires to California Museum". NASA Armstrong Flight Research Center Website. Retrieved 2015-05-02.
^ ^a ^b ^c ^d Francillon 1982, pp. 434-439
^ "Airframe Dossier - Lockheed YO-3A-LM Quiet Star, s/n 69-18000 US, c/n 001". Aerial Visuals. Retrieved 16 November 2020.
^ "Aircraft on Display". Hiller Aviation Museum. Retrieved 16 November 2020.
^ "Airframe Dossier - Lockheed YO-3A Quiet Star, s/n 69-18001 USAF, c/n 002". Aerial Visuals. Retrieved 16 November 2020.
^ "Lockheed YO-3A Quiet Star". Museum of Flight. Retrieved 16 November 2020.
^ "Lockheed YO-3A Quietstar". Pima Air & Space Museum. Retrieved 16 November 2020.
^ "YO-3A "Quiet Star" Silent Stealth Airplane". Vietnam Helicopters Museum. 11 February 2015. Retrieved 16 November 2020.

Bibliography

Andrade, John. U.S. Military Aircraft Designations and Serials since 1909. Hinckley, UK: Midland Counties Publications, 1979. ISBN 0-904597-22-9.
Francillon, René J. (1982). Lockheed Aircraft since 1913. London: Putnam & Company. ISBN 0-370-30329-6.
The Illustrated Encyclopedia of Aircraft (Part Work 1982-1985). London: Orbis Publishing, 1985.
Munson, Kenneth. Bombers in Service, Patrol and Transport Aircraft Since 1960. London: The Macmillan Co., 1972. ISBN 978-0-71370-586-7.

Schnebly, F. David. A Greenhouse Anthology, Chapter 5: Taking The Night Away From Charlie (Development of the YO-3A). Xlibris Corporation, 2000 (ISBN 0-7388-3086-0)